Mitsubishi Lancer Evolution VIII MR Technical Information Page 55
- Page / 129
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
13A-16
MPI – TROUBLESHOOTING
Check the purge control solenoid valve (Refer to Section
17: Checking the exhaust gas purification system)
MUT-II/III Service data
• No.11 O
2
sensor (Ref: P13A-83)*
Refer to the diagnosis code classification table (P13A-6)
MUT-II/III diagnosis code
• Is the diagnosis code displayed?
Check the timing of ignition (Ref Section 11, Engine
tuning)
Check the sound made by the injector (using a
soundscope)
Check the crank angle sensor and the fitting of the timing
belt cover
If there is abnormality in the exhaust gases and code
Nos. P0201~P0204 are recorded, check the injector
system
If abnormal sensor data is recorded, carry out inspections
for each diagnosis code in order (Ref: P13A-6)
Replace the purge control solenoid valve
Code No.P0130: O
2
sensor system inspection (Ref:
P13A-16)*
Go on to next page.
MUT-II/III Service data
• No.13: Intake air temperature sensor
• No.14: TPS
• No.21: Water temperature sensor
• No.25: Atmospheric pressure sensor
• No.95: MAP sensor
(Ref: P13A-24)
<Reference>
Proceed to OK if all service data levels are normal.
Proceed via NG even if only one of the service data
levels is abnormal.
*: Refer to the 03-1 Service Manual for the Lancer Evolution VIII (No.1036K07)
NO
OK
OK
OK
OK
OK
YES
NG
NG
NG
NG
Inspection procedure Fault to be checked Reference page
11
Engine seems hesitant
13A-16
Acceleration malfunction
Engine seems to stumble
Engine has a power surge
15 Mis-timed ignition 13A-18
35 Inter-cooler water spray circuit system 13A-19
37 No.2 waste gate solenoid valve system 13A-21
38 Air temperature sensor system 13A-22
Engine seems hesitant, acceleration malfunction, engine
seems to stumble, engine has a power surge
Probable causes of the malfunction
Probable causes of the malfunction are noted in the right hand
column.
• Malfunction of the air/fuel mixing control system
• Malfunction of the ignition system
• Malfunction of the fuel system
• Malfunction of the intake system
• Malfunction of the exhaust gas purification system
• Failure of compression pressure
• Malfunction of the turbocharger system
5. Inspection procedure for each type of fault
Inspection procedure 11
4. Checklist of faults
- Evolution - IX 1
- SERVICE MANUAL 2
- EVOLUTION IX 3
- Related materials 4
- SECTION 00 5
- SECTION 11 6
- ENGINE – SPECIAL TOOLS 7
- Engine tuning 9
- Camshaft, valve stem seal 9
- During assembly, apply 11
- Removal guidelines 14
- Fitting guidelines 14
- Cylinder head gasket 19
- ENGINE – CYLINDER HEAD GASKET 20
- TIMING BELT, TIMING BELT B 25
- ENGINE ASSY 33
- ENGINE – ENGINE ASSY 34
- SECTION 13A 40
- MPI – GENERAL 41
- Servicing standards 42
- Special tools 42
- MPI- SPECIAL TOOLS 43
- MPI – TROUBLESHOOTING 44
- TROUBLESHOOTING 44
- MPI- TROUBLESHOOTING 45
- Code No. Diagnosis item Page 45
- On-vehicle servicing 68
- MPI – ON-VEHICLE SERVICING 69
- ENGINE COOLING 70
- ENGINE COOLING – WATER PUMP 71
- Water pump 71
- Water hose and pipe 72
- INTAKE & EXHAUST 74
- Inter-cooler water spray 75
- Secondary air control system 77
- Inlet manifold 78
- Removal and fitting 81
- EXHAUST MANIFOLD 82
- ENGINE ELECTRICAL 84
- (engine oil) 85
- Ignition system 87
- REAR AXLE 88
- WHEELS AND TYRES 89
- FRONT SUSPENSION 91
- FRONT SUSPENSION – STRUT ASSY 92
- SECTION 42 93
- EXTERIOR 94
- EXTERIOR – FRONT BUMPER 95
- Front bumper 95
- Rear bumper 97
- EXTERIOR – REAR BUMPER 98
- EXTERIOR – MARKINGS 99
- Markings 99
- SRS AIRBAG 100
- CHASSIS ELECTRICAL 100
- Service Manual 102
- Supplement 102
- Lancer Evolution IX 102
- HOW TO USE THIS MANUAL 104
- How to Use this Manual 104
- Tightening Torques 107
- 4G6 – TIGHTENING TORQUES 107
- 4G6 – TIGHTENING TORQUE 108
- 4G6 - TIGHTENING TORQUES 109
- Sealants 109
- Alternator / Ignition System 110
- Removal Service Point 111
- 4G6 – TIMING BELT 112
- Timing Belt 112
- Installation Service Point 113
- 4G6 – FUEL SYSTEM 115
- Fuel System 115
- Removal and Installation 117
- Removal Sequence 117
- 4G6 – EXHAUST MANIFOLD 118
- Exhaust Manifold 118
- Water Pump / Water Hose 119
- 4G6 – ROCKER ARM / CAMSHAFT 120
- Rocker Arm / Camshaft 120
- 4G6 – OIL PUMP / SUMP 123
- Oil Pump / Oil Pan 123
- Piston / Connecting Rod 124
- 4G6 – PISTONS CONNECTING RODS 126
- Inspection 126
- Crankshaft / Cylinder Block 127
- 4G6 – TURBOCHARGER 129
- Turbocharger 129
Related products and manuals for Cars Mitsubishi Lancer Evolution VIII MR
Cars Mitsubishi 2014 OUTLANDER User Manual
(32 pages)
(32 pages)
Cars Mitsubishi Montero 1987 User Manual
(1 pages)
(1 pages)
Cars Mitsubishi i-MiEV User Manual
(11 pages)
(11 pages)
Cars Mitsubishi Montero 1987 User Manual
(8 pages)
(8 pages)
© 2020, manymanuals.com. All rights reserved. | 0.916 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals